Kia Rio: Fuel Delivery System / Fuel Filter

Kia Rio 2017-2020 YB Service Manual / Engine Control / Fuel System / Fuel Delivery System / Fuel Filter

Repair procedures
Removal
1.

Remove the fuel pump.

(Refer to Fuel Delivery System - "Fuel Pump")

2.

Disconnect the fuel pump motor connector (A) and fuel sender connector (B).

3.

Disconnect the fuel feed tube quick-connector (A) after removing the fixing clip (B).

4.

Remove the cushion pipe fixing clip (A), and then separate the head assembly (B) from reservoir cup.

5.

Press the fixing hook (A) with a driver and then remove fuel sender in the arrow direction.

6.

Remove the reservoir-cup (B) after releasing the fixing hooks (A).

7.

Disconnect the ground pin (A).

8.

Remove the fixing clip (A), and then assist pump assembly (B).

9.

Remove the free-filter (A) after releasing the fixing hooks.

10.

Separate the electric pump motor (A).

11.

Replace new fuel filter.

Installation
1.

Install in the reverse order of removal.

Fuel Pump
Repair procedures Inspection [Fuel pump] 1. Turn ignition switch OFF and disconnect the negative (-)battery cable. 2. Remove the fuel pump assembl ...

Fuel Pump Motor
Repair procedures Removal 1. Remove the fuel pump. (Refer to Fuel Delivery System - "Fuel Pump") 2. Disconnect the fuel pump motor con ...

Other information:

Kia Rio 2017-2020 YB Owners Manual: Windshield washers (front)


■ Type A ■ Type B In the OFF position, pull the lever gently toward you to spray washer fluid on the windshield and to run the wipers 1-3 cycles. Use this function when the windshield is dirty. The spray and wiper operation will continue until you release the lever. If the washer doe ...

Kia Rio 2017-2020 YB Owners Manual: Sliding the sunroof


To open the sunroof automatically: Pull the sunroof control lever backward to the second detent position and then release it. The sunroof will slide all the way open. The sunroof will slide to the recommended open position (5 cm (about 2 in.) before the maximum slide open position). To stop ...

Copyright © www.krioyb.com 2017-2020